GHS Classification Result
PHYSICAL HAZARDS
HEALTH HAZARDS
ENVIRONMENTAL HAZARDS
NOTE:
Reference：
Chemical Name：Diisobutylamine
CAS：110-96-3
Result：
| ID: | 21A3564 |
| Classifier: | Ministry of Health, Labour and Welfare （MHLW）, Ministry of the Environment （MOE） |
| Year Classified: | FY2009 |
| Reference Manual: | GHS Classification Guidance by the Japanese Government （March, 2009） |
PHYSICAL HAZARDS
| Hazard class | Classification | Symbol | Signal word | Hazard statement | Precautionary statement | Rationale for the classification | |
|---|---|---|---|---|---|---|---|
| 1 | Explosives | Not applicable | - | - | - | - | There are no chemical groups associated with explosive properties present in the molecules. |
| 2 | Flammable gases （including chemically unstable gases） | Not applicable | - | - | - | - | Liquid (GHS definition) |
| 3 | Aerosols | Not applicable | - | - | - | - | Not aerosol products. |
| 4 | Oxidizing gases | Not applicable | - | - | - | - | Liquid (GHS definition) |
| 5 | Gases under pressure | Not applicable | - | - | - | - | Liquid (GHS definition) |
| 6 | Flammable liquids | Category 3 |
|
Warning | H226: Flammable liquid and vapour |
P303+P361+P353: IF ON SKIN （or hair）: Remove/Take off immediately all contaminated clothing. Rinse skin with water/shower. P370+P378: In case of fire: Use ... for extinction. P403+P235: Store in a well-ventilated place. Keep cool. P210: Keep away from heat/sparks/open flames/hot surfaces. - No smoking. P233: Keep container tightly closed. P240: Ground/bond container and receiving equipment. P241: Use explosion-proof electrical/ventilating/lighting/.../equipment. P242: Use only non-sparking tools. P243: Take precautionary measures against static discharge. P280: Wear protective gloves/protective clothing/eye protection/face protection. P501: Dispose of contents/container to ... |
Classified into Category 3 since flash point 29 degC (closed-cup) (HSDB (2002)) is >=23 degC and <=60 degC. The substance is classified into Class 3, Subsidiary risk 8, PG III in UNRTDG (UN2361). |
| 7 | Flammable solids | Not applicable | - | - | - | - | Liquid (GHS definition) |
| 8 | Self-reactive substances and mixtures | Not applicable | - | - | - | - | There are no chemical groups present in the molecule associated with explosive or self-reactive properties. |
| 9 | Pyrophoric liquids | Not classified | - | - | - | - | Auto-ignition point is 290 degC (Hommel (1996)) exceeding 70 degC. |
| 10 | Pyrophoric solids | Not applicable | - | - | - | - | Liquid (GHS definition) |
| 11 | Self-heating substances and mixtures | Classification not possible | - | - | - | - | Test methods applicable to liquid substances are not available. |
| 12 | Substances and mixtures which, in contact with water, emit flammable gases | Not applicable | - | - | - | - | The chemical structure of the substance does not contain metals or metalloids (B, Si, P, Ge, As, Se, Sn, Sb, Te, Bi, Po, At). |
| 13 | Oxidizing liquids | Not applicable | - | - | - | - | Organic compounds containing no oxygen, fluorine or chlorine |
| 14 | Oxidizing solids | Not applicable | - | - | - | - | Liquid (GHS definition) |
| 15 | Organic peroxides | Not applicable | - | - | - | - | Organic compounds containing no bivalent -O-O- structure |
| 16 | Corrosive to metals | Classification not possible | - | - | - | - | No data available. |
| Hazard class | Classification | Symbol | Signal word | Hazard statement | Precautionary statement | Rationale for the classification | |
|---|---|---|---|---|---|---|---|
| 1 | Acute toxicity （Oral） | Category 3 |
|
Danger | H301: Toxic if swallowed |
P301+P310: IF SWALLOWED: Immediately call a POISON CENTER or doctor/physician. P264: Wash ... thoroughly after handling. P270: Do not eat, drink or smoke when using this product. P321: Specific treatment （see ... on this label）. P330: Rinse mouth. P405: Store locked up. P501: Dispose of contents/container to ... |
Based on a LD50 value of 258 mg/kg bw for rats (PATTY (5th, 2001)), the substance was classified into Category 3. |
| 1 | Acute toxicity （Dermal） | Category 2 |
|
Danger | H310: Fatal in contact with skin |
P302+P350: IF ON SKIN: Gently wash with plenty of soap and water. P262: Do not get in eyes, on skin, or on clothing. P264: Wash ... thoroughly after handling. P270: Do not eat, drink or smoke when using this product. P280: Wear protective gloves/protective clothing/eye protection/face protection. P310: Immediately call a POISON CENTER or doctor/physician. P322: Specific treatment （see ... on this label）. P361: Remove/Take off immediately all contaminated clothing. P363: Wash contaminated clothing before reuse. P405: Store locked up. P501: Dispose of contents/container to ... |
Based on a LD50 value of 186.25 mg/kg bw for rabbits (HSDB (2002)), the substance was classified into Category 2. |
| 1 | Acute toxicity （Inhalation: Gases） | Not applicable | - | - | - | - | Liquid (GHS definition) |
| 1 | Acute toxicity （Inhalation: Vapours） | Category 1 |
|
Danger | H330: Fatal if inhaled |
P304+P340: IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. P403+P233: Store in a well-ventilated place. Keep container tightly closed. P260: Do not breathe dust/fume/gas/mist/vapours/spray. P271: Use only outdoors or in a well-ventilated area. P284: Wear respiratory protection. P310: Immediately call a POISON CENTER or doctor/physician. P320: Specific treatment is urgent （see ... on this label）. P405: Store locked up. P501: Dispose of contents/container to ... |
Based on a mortality rate of 4/6 in rats exposed at 75 ppm for 4-hour (LC50 <100 ppm) (HSDB (2002)), the substance was classified into Category 1. Since the test concentration (75 ppm) was lower than 90% of saturated vapour pressure concentration (9,566 ppm), the classification criteria for gas was adopted as test for vapour. |
| 1 | Acute toxicity （Inhalation: Dusts and mists） | Classification not possible | - | - | - | - | No data available. |
| 2 | Skin corrosion/irritation | Classification not possible | - | - | - | - | No data available. |
| 3 | Serious eye damage/eye irritation | Classification not possible | - | - | - | - | No data available. |
| 4 | Respiratory sensitization | Classification not possible | - | - | - | - | No data available. |
| 4 | Skin sensitization | Classification not possible | - | - | - | - | No data available. |
| 5 | Germ cell mutagenicity | Classification not possible | - | - | - | - | Classification not possible due to lack of data from in vivo mutagenicity tests. From in vitro mutagenicity tests, there is a report of a negative Ames test (NTP DB (access on Aug. 2009)). |
| 6 | Carcinogenicity | Classification not possible | - | - | - | - | No data available. |
| 7 | Reproductive toxicity | Classification not possible | - | - | - | - | No data available. |
| 8 | Specific target organ toxicity - Single exposure | Classification not possible | - | - | - | - | No data available. |
| 9 | Specific target organ toxicity - Repeated exposure | Classification not possible | - | - | - | - | No data available. |
| 10 | Aspiration hazard | Classification not possible | - | - | - | - | No data available. |
| Hazard class | Classification | Symbol | Signal word | Hazard statement | Precautionary statement | Rationale for the classification | |
|---|---|---|---|---|---|---|---|
| 11 | Hazardous to the aquatic environment （Acute） | Category 3 | - | - | H402: Harmful to aquatic life |
P273: Avoid release to the environment. P501: Dispose of contents/container to ... |
Classified into Category 3 from its 48h-EC50 = 35 mg/L for Crustacea (Daphnia magna) (AQUIRE, 2010). |
| 11 | Hazardous to the aquatic environment （Long-term） | Not classified | - | - | - | - | Classified into Not classified since it is rapidly degradable (Readily biodegradable, BOD degradation rate: 63 - 87% (Biodegradation and Bioconcentration of Existing Chemical Substances under the Chemical Substances Control Law, 1991)) and its bioaccumulative potential is estimated to be low (log Kow = 2.63 (PHYSPROP Database, 2009) though its acute toxicity is Category 3. |
NOTE:
|
* Classification was conducted by relevant Japanese Ministries in accordance with GHS Classification Guidance for the Japanese Government, and is intended to provide a reference for preparing GHS labelling and SDS for users. * This is a provisional English translation of classification results and is subject to revision without notice. * The responsibility for any resulting GHS labelling and SDS referenced from this site is with users. |
Reference：
|
Reference Manual |
|
|
Definitions / Abbreviations |
|
|
Model Label by MHLW |
MHLW Website （in Japanese Only） |
|
Model SDS by MHLW |
MHLW Website （in Japanese Only） |