GHS Classification Result
PHYSICAL HAZARDS
HEALTH HAZARDS
ENVIRONMENTAL HAZARDS
NOTE:
Reference：
Chemical Name：2,3-epoxypropionaldehyde
CAS：765-34-4
Result：
| ID: | 677 |
| Classifier: | Inter-ministerial Committee on GHS |
| Year Classified: | FY2006 |
| Reference Manual: | GHS Classification Manual （10 Feb, 2006） |
PHYSICAL HAZARDS
| Hazard class | Classification | Symbol | Signal word | Hazard statement | Precautionary statement | Rationale for the classification | |
|---|---|---|---|---|---|---|---|
| 1 | Explosives | Not applicable | - | - | - | - | There are no chemical groups associated with explosive properties present in the molecules. |
| 2 | Flammable gases （including chemically unstable gases） | Not applicable | - | - | - | - | Liquid (GHS definition) |
| 3 | Aerosols | Not applicable | - | - | - | - | Not aerosol products |
| 4 | Oxidizing gases | Not applicable | - | - | - | - | Liquid (GHS definition) |
| 5 | Gases under pressure | Not applicable | - | - | - | - | Liquid (GHS definition) |
| 6 | Flammable liquids | Category 3 |
|
Warning | H226: Flammable liquid and vapour |
P303+P361+P353: IF ON SKIN （or hair）: Remove/Take off immediately all contaminated clothing. Rinse skin with water/shower. P370+P378: In case of fire: Use ... for extinction. P403+P235: Store in a well-ventilated place. Keep cool. P210: Keep away from heat/sparks/open flames/hot surfaces. - No smoking. P233: Keep container tightly closed. P240: Ground/bond container and receiving equipment. P241: Use explosion-proof electrical/ventilating/lighting/.../equipment. P242: Use only non-sparking tools. P243: Take precautionary measures against static discharge. P280: Wear protective gloves/protective clothing/eye protection/face protection. P501: Dispose of contents/container to ... |
Category 3 because of its flash point: 31degC |
| 7 | Flammable solids | Not applicable | - | - | - | - | Liquid (GHS definition) |
| 8 | Self-reactive substances and mixtures | Not classified | - | - | - | - | Not classified based on UNRTDG Class: 3, though containing distorted ring (epoxide groups) as chemical groups associated with self-reactive properties present |
| 9 | Pyrophoric liquids | Not classified | - | - | - | - | Based on the UNRTDG class 3 (subsidiary risks 6.1), it was classified as the outside of Category. |
| 10 | Pyrophoric solids | Not applicable | - | - | - | - | Liquid (GHS definition) |
| 11 | Self-heating substances and mixtures | Not classified | - | - | - | - | Not classified because of UNRTDG Class: 3, Subsidiary risks Class: 6.1 |
| 12 | Substances and mixtures which, in contact with water, emit flammable gases | Not applicable | - | - | - | - | The chemical structure of the substance does not contain metals or metaloids(B, Si, P, Ge, As, Se, Sn, Sb, Te, Bi, Po, At). |
| 13 | Oxidizing liquids | Not applicable | - | - | - | - | Organic compounds containing oxygen (but not chlorine and fluorine) chemically bonded only to carbon (but not to other elements). |
| 14 | Oxidizing solids | Not applicable | - | - | - | - | Liquid (GHS definition) |
| 15 | Organic peroxides | Not applicable | - | - | - | - | Organic compounds containing no -0-0- structure |
| 16 | Corrosive to metals | Classification not possible | - | - | - | - | No data available |
| Hazard class | Classification | Symbol | Signal word | Hazard statement | Precautionary statement | Rationale for the classification | |
|---|---|---|---|---|---|---|---|
| 1 | Acute toxicity （Oral） | Category 3 |
|
Danger | H301: Toxic if swallowed |
P301+P310: IF SWALLOWED: Immediately call a POISON CENTER or doctor/physician. P264: Wash ... thoroughly after handling. P270: Do not eat, drink or smoke when using this product. P321: Specific treatment （see ... on this label）. P330: Rinse mouth. P405: Store locked up. P501: Dispose of contents/container to ... |
Category 3 based on SPECIES: Rat; ENDPOINT: LD50; VALUE:230mg/kg; REFERENCE SOURCE: PATTY (5th, 2001) |
| 1 | Acute toxicity （Dermal） | Category 3 |
|
Danger | H311: Toxic in contact with skin |
P302+P352: IF ON SKIN: Wash with plenty of soap and water. P280: Wear protective gloves/protective clothing/eye protection/face protection. P312: Call a POISON CENTER or doctor/physician if you feel unwell. P322: Specific treatment （see ... on this label）. P361: Remove/Take off immediately all contaminated clothing. P363: Wash contaminated clothing before reuse. P405: Store locked up. P501: Dispose of contents/container to ... |
It was set as Category 3 based on rabbit LD50= 249mg/kg (HSDB (2003)). |
| 1 | Acute toxicity （Inhalation: Gases） | Not applicable | - | - | - | - | Liquid (GHS definition) |
| 1 | Acute toxicity （Inhalation: Vapours） | Category 2 |
|
Danger | H330: Fatal if inhaled |
P304+P340: IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. P403+P233: Store in a well-ventilated place. Keep container tightly closed. P260: Do not breathe dust/fume/gas/mist/vapours/spray. P271: Use only outdoors or in a well-ventilated area. P284: Wear respiratory protection. P310: Immediately call a POISON CENTER or doctor/physician. P320: Specific treatment is urgent （see ... on this label）. P405: Store locked up. P501: Dispose of contents/container to ... |
The saturated vapor pressure concentration of this product is 59800ppm, and it is thought that all inhalation tests were done with vapor. It was classified as Category 2 based on rat LC50 = 251ppm (PATTY (5th, 2001)). |
| 1 | Acute toxicity （Inhalation: Dusts and mists） | Classification not possible | - | - | - | - | No data available |
| 2 | Skin corrosion/irritation | Category 2 |
|
Warning | H315: Causes skin irritation |
P302+P352: IF ON SKIN: Wash with plenty of soap and water. P332+P313: If skin irritation occurs: Get medical advice/attention. P264: Wash ... thoroughly after handling. P280: Wear protective gloves/protective clothing/eye protection/face protection. P321: Specific treatment （see ... on this label）. P362: Take off contaminated clothing and wash before reuse. |
It was classified as Category 2 based on the statement that moderate skin irritation was observed on rabbits (HSDB (2003)). |
| 3 | Serious eye damage/eye irritation | Category 2A |
|
Warning | H319: Causes serious eye irritation |
P305+P351+P338: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P337+P313: If eye irritation persists: Get medical advice/attention. P264: Wash ... thoroughly after handling. P280: Wear protective gloves/protective clothing/eye protection/face protection. |
Based on statements with the irritation of moderate in rabbit (PATTY (5th, 2001)), and with the irritation in human (HSDB (2003)) , it was set as Category 2A. |
| 4 | Respiratory sensitization | Classification not possible | - | - | - | - | No data available |
| 4 | Skin sensitization | Classification not possible | - | - | - | - | No data available |
| 5 | Germ cell mutagenicity | Category 2 |
|
Warning | H341: Suspected of causing genetic defects |
P308+P313: IF exposed or concerned: Get medical advice/attention. P201: Obtain special instructions before use. P202: Do not handle until all safety precautions have been read and understood. P281: Use personal protective equipment as required. P405: Store locked up. P501: Dispose of contents/container to ... |
We found no in vivo test results, however, it has two indices for in vitro mutagenicity test (it shows positive in the bacteria reverse mutation test and the gene mutation test using the mammalian cells (MLA) (PATTY (5th, 2001), IRIS (2005)). In addition, this product has structural analogy with glycidol (ID 0098, CAS 556-52-9, in vivo somatic mutagenicity positive)), it has a similar structure with ethylene oxide, a known productive cell mutagen, and it has the alert structure (epoxide) there. In addition this product is metabolized and converted into glycidol. Therefore we classified it as Category 2. |
| 6 | Carcinogenicity | Category 2 |
|
Warning | H351: Suspected of causing cancer |
P308+P313: IF exposed or concerned: Get medical advice/attention. P201: Obtain special instructions before use. P202: Do not handle until all safety precautions have been read and understood. P281: Use personal protective equipment as required. P405: Store locked up. P501: Dispose of contents/container to ... |
Based on being classified into 2B according to IARC (1987), it was set as 2 by the technical indicator. |
| 7 | Reproductive toxicity | Classification not possible | - | - | - | - | No data available |
| 8 | Specific target organ toxicity - Single exposure | Category 3 （Respiratory tract irritation） |
|
Warning | H335: May cause respiratory irritation (respiratory tract irritation) |
P304+P340: IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. P403+P233: Store in a well-ventilated place. Keep container tightly closed. P261: Avoid breathing dust/fume/gas/mist/vapours/spray. P271: Use only outdoors or in a well-ventilated area. P312: Call a POISON CENTER or doctor/physician if you feel unwell. P405: Store locked up. P501: Dispose of contents/container to ... |
There is the description that it has irritation to nose and throat in human (PATTY (5th, 2001)), and the description that it has irritation to the respiratory to the lung in rat (HSDB (2003)), it is classified into Category 3 (respiratory irritation). |
| 9 | Specific target organ toxicity - Repeated exposure | Category 1 (kidney) |
|
Danger | H372: Cause damage to organs through prolonged or repeated exposure (kidney) |
P260: Do not breathe dust/fume/gas/mist/vapours/spray. P264: Wash ... thoroughly after handling. P270: Do not eat, drink or smoke when using this product. P314: Get medical advice/attention if you feel unwell. P501: Dispose of contents/container to ... |
It was classified to as Category 1 (kidney) according to the statement that in the rat, an edema of renal pelvis was seen with the given dose of guidance value within the limits of Category 1(IRIS 0315 (2001)) . |
| 10 | Aspiration hazard | Classification not possible | - | - | - | - | No data available |
| Hazard class | Classification | Symbol | Signal word | Hazard statement | Precautionary statement | Rationale for the classification | |
|---|---|---|---|---|---|---|---|
| 11 | Hazardous to the aquatic environment （Acute） | Classification not possible | - | - | - | - | No data available |
| 11 | Hazardous to the aquatic environment （Long-term） | Classification not possible | - | - | - | - | No data available. |
NOTE:
|
* Classification was conducted by relevant Japanese Ministries in accordance with GHS Classification Guidance for the Japanese Government, and is intended to provide a reference for preparing GHS labelling and SDS for users. * This is a provisional English translation of classification results and is subject to revision without notice. * The responsibility for any resulting GHS labelling and SDS referenced from this site is with users. |
Reference：
|
Reference Manual |
|
|
Definitions / Abbreviations |
|
|
Model SDS by MHLW |
MHLW Website （in Japanese Only） |